Many South Africans are unknowingly shortening the lifespan of their vehicles through poor maintenance habits and everyday driving behaviours.

According to Pieter Niemand, national director of the Motor Industry Workshop Association (MIWA), an association of the Retail Motor Industry Organisation (RMI), a combination of neglect, misinformation, and cost-cutting shortcuts is leading to avoidable and often expensive damage.

“As reputable mechanics, we see the same issues repeatedly. Motorists can add years to the life of their vehicles simply by adopting better driving habits and sticking to the correct maintenance schedule,” said Niemand.

Below, MIWA outlined some of the most common – and sometimes surprising – mistakes motorists make, along with practical tips to protect their vehicles.

ALSO READ: Suspects at large following Edelweiss house burglary

Not understanding the vehicle’s maintenance schedule
Many motorists underestimate the importance of regular, scheduled maintenance. Insurance covers breakages, no maintenance, and delaying routine checks or using unqualified service providers often leads to further damage.

Niemand stressed that every driver should know how to check basic fluid levels and always choose a reputable, accredited workshop.

MIWA tip: Never skip a service just because the car “sounds fine”.

Ignoring warning lights and dash messages
Disregarding cluster warnings is one of the most costly mistakes drivers make. Continuing to drive with flashing engine lights can result in major engine or gearbox failure, fuel system damage, or compromised braking.

MIWA tip: If the light is flashing, treat it as an emergency and stop driving immediately.

Choosing the cheapest workshop or DIY fixes
Cheaper is not always better. MIWA-accredited workshops follow strict compliance, safety, diagnostic, and training standards.

Unregulated workshops often lack the tools or expertise to work on modern, electronically controlled systems.

MIWA tip: Look for MIWA and RMI branding and certification for peace of mind.

Skipping oil changes or using poor-quality oil
“Your engine oil is the lifeblood of your car,” said Niemand. Using the incorrect oil grade or inferior products leads to sludge build-up, overheating, premature wear, and turbocharger damage.

MIWA tip: Always follow manufacturer specifications – never ‘thumb-suck’.

Driving aggressively from a cold start

Revving hard when the engine is still cold is extremely damaging. Cold oil does not lubricate effectively, leading to timing chain stretch, piston ring wear, and early turbo problems.

MIWA tip: Allow 30 – 60 seconds of gentle driving before increasing speed.

Riding the clutch and poor gearbox habits

“Many gearbox failures are caused by the driver, not the gearbox,” said Niemand.

Resting a foot on the clutch, holding the car on an incline, or forcing gear changes causes unnecessary friction and overheating.

Running the fuel tank too low
Fuel cools and lubricates the pump. Constantly running below a quarter tank can damage injectors and fuel pumps and draw debris into the system – repairs that are increasingly costly in modern vehicles.

Neglecting filters and belts
Air filters, fuel filters, and timing belts are essential to engine health. Failure to replace them at the right intervals can cause poor performance or catastrophic engine failure.

MIWA tip: Never use inferior-quality filters that may collapse or fail.

Incorrect tyre pressure and wheel neglect
Low tyre pressure and poor wheel alignment affect far more than tyres – they put strain on suspension, steering components, wheel bearings and CV joints.

MIWA tip: Check tyre pressure monthly and align wheels twice a year.

Overloading the vehicle
Constantly carrying loads beyond the vehicle’s design capacity places excessive stress on suspension, brakes, tyres, and even the gearbox.

“Your vehicle was engineered for a specific payload. Consistently exceeding it shortens its lifespan dramatically,” said Niemand.

Neglecting cooling system maintenance
Overheating is a major cause of engine failure. Using plain water instead of proper coolant, ignoring leaks, or failing to replace coolant at recommended intervals puts engines at high risk.

MIWA tip: A correct antifreeze/coolant mix is vital in South Africa’s climate.
Poor driving style
Smooth driving is one of the simplest ways to protect vehicle components. Harsh acceleration, sudden braking, and inconsistent speeds increase wear across the engine, brakes, and drivetrain.

“Good driving habits are the cheapest form of preventative maintenance,” noted Niemand.

Niemand concluded by saying that motorists can significantly extend the life of their vehicles by adopting better driving habits and following the correct maintenance schedule. A reputable MIWA-accredited workshop is always the best partner to help you care for your car properly.

ALSO READ: Springs inwoner neem leisels oor as laerskool hoof